Ford Fiesta Mk6 1.25 82bhp — Shock Absorber Oil Leak and Failure
Shock absorbers lose their damping efficiency over time, and eventually blow their seals, leaking hydraulic fluid.
Severity
ModerateDIY Difficulty
Moderate
Est. Cost
£200–£400
OBD Codes
None
Suspension
Typical layout and location for the Suspension assembly.
Symptoms
- Car bounces multiple times after hitting a bump
- Visibly wet, oily residue running down the outside of the shock absorber body
- Increased body roll in corners and longer braking distances
Root Cause
The internal rubber seals wear out from millions of oscillations. Grit on the damper shaft accelerates the wear, tearing the seal.
How To Fix
- Perform a 'bounce test' on each corner of the car — it should settle immediately after one rebound.
- Replace dampers in axle pairs.
- Consider replacing top mounts and bump stops simultaneously to save on future labour.
- Cost: £200-400 per pair.
Estimated Repair Costs
| Repair Option | Est. Cost (GBP) |
|---|---|
| DIY (parts only) | £80–£160 |
| Independent Garage | £200–£400 |
| Main Dealership | £320–£640 |
Other Faults on This Variant
Front Wheel Bearing Failure
ModerateFront wheel bearing wear is extremely common on the Mk6 Fiesta. Most examples will need at least one bearing replaced between 60,000 and 100,000 miles.
Power Steering Pump Failure
ModerateThe hydraulic power steering pump on the Mk6 Fiesta fails with age and mileage, making the steering very heavy — especially at low speeds and when parking.
Ignition Coil Pack Failure
ModerateThe single coil pack block fails, causing a 2-cylinder misfire.
Disclaimer: Repair cost estimates are indicative and based on community data. Always get a quote from a qualified mechanic before proceeding with any repair.