MinorAffected: 2012-201730,000–80,000 miles

Ford Fiesta Mk7 1.0 EcoBoost 100bhp — Front Anti-Roll Bar Drop Link Wear

The front anti-roll bar drop links wear out on heavily potholed UK roads, causing an annoying knocking sound at low speeds.

Severity

Minor

DIY Difficulty

Easy

Est. Cost

£60–£120

OBD Codes

None

Symptoms

Light knocking or rattling noise from the front suspension over rough roads
Noise is most pronounced at 10-20mph over speed bumps

Root Cause

The ball joints at either end of the drop link lose their grease and the nylon cups wear out, creating play in the joint.

How To Fix

Jack the car and check for vertical play in the drop link.
Replace in pairs (left and right) for best results.
A very simple DIY job, but the nuts are often seized and need to be cut off.
Cost: £60-120 at a garage.

Estimated Repair Costs

Repair Option	Est. Cost (GBP)
DIY (parts only)	£24–£48
Independent Garage	£60–£120
Main Dealership	£96–£192

Other Faults on This Variant

Timing Chain Stretch and Tensioner Failure

Critical

2012-201540,000–100,000 miles£600–£1200

Pre-2016 Ford 1.0 EcoBoost engines suffer from premature timing chain stretch. The plastic tensioner can fail, causing catastrophic engine damage with little warning.

Coolant Loss from Cylinder Head

Severe

2012-201860,000–120,000 miles£500–£900

The 1.0 EcoBoost has an integrated exhaust manifold cast into the cylinder head. This design causes head gasket stress and coolant loss, sometimes causing overheating.

Thermostat Failure and Overheating Risk

Moderate

2012-201850,000–100,000 miles£80–£180

The plastic thermostat housing on the 1.0 EcoBoost is prone to cracking. A stuck-open thermostat causes the engine to run cold and burn more fuel; a stuck-closed thermostat causes rapid overheating.

Disclaimer: Repair cost estimates are indicative and based on community data. Always get a quote from a qualified mechanic before proceeding with any repair.