SevereAffected: 2004-201160,000–120,000 miles

Ford Focus Mk2 1.6 TDCi 110bhp — Suspension Coil Spring Snapping

A very common MOT failure in the UK. Suspension coil springs corrode and snap, usually near the bottom pigtail.

Severity

Severe

DIY Difficulty

Hard

Est. Cost

£150–£300

OBD Codes

None

Component Diagram

Suspension

Typical layout and location for the Suspension assembly.

Reference Illustration

Symptoms

Loud 'twang' or bang when turning the steering wheel at low speeds
Car sits noticeably lower on one side
Grating noise over bumps

Root Cause

The protective coating on the steel spring chips from stone impacts. Salt water corrodes the exposed steel, weakening the spring until it fractures under load.

How To Fix

Visually inspect all four springs for fractures at the very bottom coil.
Always replace coil springs in pairs across an axle to maintain handling balance.
Cost: £150-300 per pair at an independent garage.

Estimated Repair Costs

Repair Option	Est. Cost (GBP)
DIY (parts only)	£60–£120
Independent Garage	£150–£300
Main Dealership	£240–£480

Other Faults on This Variant

EGR Valve Failure

Moderate

2005-201160,000–120,000 miles£80–£300

The EGR valve is a common failure on the 1.6 TDCi engine, causing power loss, rough idle, and excessive smoke.

Dual Mass Flywheel (DMF) Failure

Severe

2004-201180,000–150,000 miles£600–£1200

DMF failure is one of the most expensive known faults on the 1.6 TDCi. Typically requires replacement of flywheel and clutch together.

Turbocharger Failure

Severe

2004-2011100,000–180,000 miles£400–£900

Turbo failure on the 1.6 TDCi is common at higher mileages, often caused by oil starvation or sludge blockage.

Disclaimer: Repair cost estimates are indicative and based on community data. Always get a quote from a qualified mechanic before proceeding with any repair.