SevereAffected: 2013-202160,000–120,000 miles

Nissan Qashqai J11 1.5 dCi 110bhp — Suspension Coil Spring Snapping

A very common MOT failure in the UK. Suspension coil springs corrode and snap, usually near the bottom pigtail.

Severity

Severe

DIY Difficulty

Hard

Est. Cost

£150–£300

OBD Codes

None

Component Diagram

Suspension

Typical layout and location for the Suspension assembly.

Reference Illustration

Symptoms

Loud 'twang' or bang when turning the steering wheel at low speeds
Car sits noticeably lower on one side
Grating noise over bumps

Root Cause

The protective coating on the steel spring chips from stone impacts. Salt water corrodes the exposed steel, weakening the spring until it fractures under load.

How To Fix

Visually inspect all four springs for fractures at the very bottom coil.
Always replace coil springs in pairs across an axle to maintain handling balance.
Cost: £150-300 per pair at an independent garage.

Estimated Repair Costs

Repair Option	Est. Cost (GBP)
DIY (parts only)	£60–£120
Independent Garage	£150–£300
Main Dealership	£240–£480

Other Faults on This Variant

Electronic Parking Brake (EPB) Motor Failure

Severe

2014-202150,000–100,000 miles£200–£300

The electronic parking brake actuators on the rear brake calipers frequently seize or burn out, leaving the handbrake stuck on or refusing to engage.

DPF Pressure Sensor Pipe Split

Moderate

2014-202160,000–100,000 miles£5–£100

A tiny rubber hose connecting the DPF to the exhaust pressure sensor splits frequently, causing limp mode and preventing DPF regeneration.

Front Radar / Anti-Collision Sensor Failure

Minor

2014-202140,000–90,000 miles£600–£800

The front radar sensor (used for emergency braking) is poorly sealed and highly vulnerable to water ingress and stone chips, causing the entire safety system to shut down.

Disclaimer: Repair cost estimates are indicative and based on community data. Always get a quote from a qualified mechanic before proceeding with any repair.