SevereAffected: 2006-201460,000–120,000 miles

Vauxhall Corsa Corsa D 1.2 85bhp — Suspension Coil Spring Snapping

A very common MOT failure in the UK. Suspension coil springs corrode and snap, usually near the bottom pigtail.

Severity

Severe

DIY Difficulty

Hard

Est. Cost

£150–£300

OBD Codes

None

Component Diagram

Suspension

Typical layout and location for the Suspension assembly.

Reference Illustration

Symptoms

Loud 'twang' or bang when turning the steering wheel at low speeds
Car sits noticeably lower on one side
Grating noise over bumps

Root Cause

The protective coating on the steel spring chips from stone impacts. Salt water corrodes the exposed steel, weakening the spring until it fractures under load.

How To Fix

Visually inspect all four springs for fractures at the very bottom coil.
Always replace coil springs in pairs across an axle to maintain handling balance.
Cost: £150-300 per pair at an independent garage.

Estimated Repair Costs

Repair Option	Est. Cost (GBP)
DIY (parts only)	£60–£120
Independent Garage	£150–£300
Main Dealership	£240–£480

Other Faults on This Variant

Coolant Loss and Head Gasket Failure

Severe

2006-201460,000–120,000 miles£400–£700

The Z12XE and Z12XEP 1.2-litre petrol engine in the Corsa D is known for coolant loss. In many cases this escalates to head gasket failure if not caught early.

Oil Pressure Switch Leak

Moderate

2006-201440,000–80,000 miles£10–£50

The oil pressure switch frequently fails internally, leaking engine oil directly into the electrical wiring loom.

Heater Blower Resistor Failure

Minor

2006-201430,000–90,000 miles£20–£50

The interior heater blower motor only works on speed setting 4. Settings 1, 2, and 3 are completely dead.

Disclaimer: Repair cost estimates are indicative and based on community data. Always get a quote from a qualified mechanic before proceeding with any repair.